Before spending capital on an air-to-air heat recovery system, any serious buyer asks the same question: how long until it pays for itself? The answer is not a mystery and it does not need specialist software, a spreadsheet and a clear method give a defensible simple-payback number that survives scrutiny from finance and from the […]
Ventiladores EC + recuperacion de calor: reducir tanto la potencia de ventilador como la carga de calefaccion
When engineers chase energy savings in a ventilation system, they usually think about the heat exchanger first and the fan second. That is backwards for part of the problem. A recovery core hands back the thermal energy in the exhaust, but the fan that pushes air through that core also consumes a large and often […]
Bakery & Oven Exhaust Heat Recovery: Taming Grease-Laden Hot Air
Walk into any commercial bakery and you feel it immediately: a wall of hot, greasy air pouring from the oven and proofer exhaust hoods, while the make-up air system fights to replace it with conditioned air pulled in from outside. That exhaust can leave at 150 to 250 degrees C carrying vaporised fat and flour […]
Recuperación de calor para lavandería comercial : captura de extracción de secadora y lavadora
A commercial laundry is a relentless consumer of energy: washers fill with hot water that goes down the drain, and dryers exhaust hot, moist, lint-laden air that must be replaced by conditioned make-up air. In a 24/7 operation like a hotel, hospital or uniform service, that load dominates the utility bill, which makes laundry one […]
Integración de recuperación aire-aire en unidades manejadoras de aire (AHU)
An air handling unit is where air-to-air heat recovery earns its keep in commercial buildings: the AHU already moves the supply and return air, so dropping a recovery core into the airstream is the lowest-cost way to reclaim energy at scale. But integration is not simply placing a wheel into the casing, where the core […]
Pool Dehumidification & Heat Recovery
A natatorium is one of the toughest HVAC environments in any building: warm water evaporates continuously, loading the air with vapour that condenses on every cold surface and rots the structure if ignored. Ventilation must remove moisture, not just heat, and the make-up air it pulls in is expensive to condition. The right air-to-air recovery […]
Recuperacion de calor en invernadero: reciclar el escape caliente para reducir las facturas de calefaccion
Cold-climate growers face a brutal conflict: crops need high air changes to control humidity and CO2, but every air change in winter throws away the expensive heat used to keep the house warm. In a grow facility the heating bill is often the largest operating cost, so recovering energy from the exhaust is one of […]
Recuperación de calor para quirófanos y salas de aislamiento hospitalarios
Hospitals ventilate harder than almost any other building type, and operating theatres and isolation wards sit at the extreme end: 20+ air changes per hour of conditioned air, strict directional pressure relationships, and zero tolerance for contaminated air reaching patients or staff. That intensity makes recovery valuable but also constrains it. This article covers where […]
Cleanroom Make-Up Air Recovery: GEP & ASHRAE 90.1
Pharmaceutical cleanrooms condition enormous volumes of 100% outdoor air to hold tight temperature, humidity and particulate limits, and that make-up air is the single largest controllable energy drain in a GMP facility. A properly specified air-to-air heat recovery core can hand back 60–75% of the sensible energy in the exhaust before it is thrown away, […]
ISO 50001 y la recuperación de calor
ISO 50001:2018, confirmed in 2024 and updated by Amendment 1:2024 (climate-action wording), is the international standard for an Energy Management System (EnMS). It does not prescribe technologies, but its structure makes heat recovery a natural “significant energy use” to control and measure. The EnMS Cycle ISO 50001 follows Plan-Do-Check-Act: Energy review — map energy sources, […]